D11R Track-Type Tractor Engine Starting with Auxiliary Start Receptacle Caterpillar


Engine Starting with Auxiliary Start Receptacle
`
D11R Track-Type Tractor [SEBU7185]
ELECTRICAL AND STARTING SYSTEM
WIRING GP
D11R Track-Type Tractor Engine Starting with Auxiliary Start Receptacle
D11R Track-Type Tractor Fuses - Replace
D11R Track-Type Tractor Circuit Breakers - Reset



Illustration 1g00123180

The auxiliary starting receptacle is on the left side of the machine.

Some AVSpare products may be equipped with auxiliary starting receptacles. All other machines can be equipped with a receptacle for parts service. A permanent receptacle is always available for jump starting.

There is a cable assembly that can be used to jump the stalled machine. The part number is 9S-3664 Plug Assembly. The 9S-3664 Plug Assembly has a 15 foot cable. You can jump the machine from another machine that is equipped with this receptacle or an auxiliary power pack. Your AVSpare dealer can provide the correct cable lengths for your application.

  1. Determine the failure of the machine to start. Refer to Special Instructions, SEHS7768 on the use of 6V-2150 Starting/Charging Analyzer .

  1. Place the transmission control in the NEUTRAL position on the stalled machine. Engage the parking brake. Lower all implements to the ground. Move all controls to the HOLD position.

  1. On the stalled machine, turn the start switch key to the OFF position. Turn all of the accessories to the OFF position.

  1. Turn the battery disconnect switch ON.

  1. Move the machine that is used for the electrical source close to the stalled machine. The cables must reach. DO NOT ALLOW THE MACHINES TO CONTACT EACH OTHER.

  1. Stop the engine on the machine that is used for the electrical source. When you use an auxiliary power source, turn the charging system to the OFF position.

  1. On the stalled machine, connect the 9S-3664 Plug Assembly to the auxiliary starting receptacle.

  1. Connect the other end of this cable to the electrical source. You must connect the cable to the auxiliary starting receptacle.

  1. Start the engine on the machine that is used for the electrical source. Also, you can energize the charging system on the auxiliary power source.

  1. Allow the electrical source to charge the batteries for two minutes.

  1. Attempt to start the stalled engine. Refer to Operation and Maintenance Manual, "Engine Starting". See the beginning of this topic.

  1. Immediately after the stalled engine starts, disconnect the jump start cable from the electrical source.

  1. Disconnect the other end of this cable from the stalled machine.

  1. Conclude with a failure analysis on the starting charging system. Check the stalled machine, as required. Check the machine when the engine is running and the charging system is in operation.

Information System:

3500B Engines for Caterpillar Built Power Modules Engine Speed Sensor
D11R Track-Type Tractor Starting Above 0°C (32°F)
3500 Generator Set Engines Cylinder Block
992G Wheel Loader and 854G Wheel Dozer Steering System Steering High Pressure System
3500B Engines for Excavators Air Inlet and Exhaust Lines
3500B Engines for Caterpillar Built Power Modules Alternator Mounting
980G Wheel Loader Bulldozing and Dumping
D11R Track-Type Tractor Engine Oil and Filter - Change
D11R Track-Type Tractor Engine Air Filter Secondary Element - Replace
824G , 825G and 826G Landfill Compactor Starting with Auxiliary Start Receptacle
D11R Track-Type Tractor Cooling System Level - Check
992G Wheel Loader and 854G Wheel Dozer Steering System Steering Control Valve (with Secondary Steering)
D11R Track-Type Tractor Starting Below 0°C (32°F) with Ether Starting Aid
3512 and 3516 EUI Engines and 784B, 785B, 789B and 793B Off-Highway Truck/Tractors Accessory Drive (Upper Right Hand)
3176C and 3196 Industrial Engines Engine Air Cleaner Element (Dual Element) - Clean/Replace
933C and 939C HYSTAT Track-Type Loaders Battery Disconnect Switch
D11R Track-Type Tractor Product Identification Number, Serial Number and EU's CE Plate Locations
980G Wheel Loader Capacities (Refill)
824G , 825G and 826G Landfill Compactor Air Conditioner - Test
3500B Engines for Caterpillar Built Power Modules Accessory Drive (Upper Right Hand)
D10R Track-Type Tractor Steering Clutch and Brake Control
3500B, 776D, 777D, 784C, 785C, 789C, 793C and and 793D Off-Highway Truck/Tractors Engine Oil Level Switch
D9R Track-Type Tractor Window Wiper and Washer Control
D11R Track-Type Tractor Ether Starting Aid